May be used to comply with OSHA Hazcom 29 CFR 1910.1200. Standards must be consulted for specific requirements.
1. IDENTIFICATION
| Product Name: | Statguard® Dissipative Neutral Floor Cleaner |
| Identified use: | Floor Cleaner |
Company Identification |
DESCO |
| Email Address: | [email protected] |
| Emergency telephone number United States: | +1 781-821-8370 |
Office hours: 8:00 AM - 5:00 PM
2. HAZARDS IDENTIFICATION
Hazard classification
This material is hazardous under the criteria of the Federal OSHA Hazcom 29 CFR 1910.1200.
| Acute toxicity (Oral) | Category 4 |
| Skin Corrosion/Irritation | Category 2 |
| Serious eye damage/eye irritation | Category 2A |
Label elements
| Hazard pictograms/Symbols: |  |
| Signal word: | WARNING |
| Hazard statements: |
Harmful if swallowed Causes skin irritation Causes serious eye irritation |
| Precautionary statements: |
Prevention Response IF SWALLOWED: Call a POISON CENTER or doctor if you feel unwell. Rinse mouth. |
3. COMPOSITION/INFORMATION ON INGREDIENTS
This product is a mixture.
| Components | CAS No. | Concentration |
| Trade Secret #000205MA104 | Trade Secret | 5 - 25% |
4. FIRST AID MEASURES
Description of first aid measures
| General advice: |
First Aid responders should pay attention to self-protection and use the recommended protective clothing (chemical resistant gloves, splash protection). If potential for exposure exists refer to Section 8 for specific personal protective equipment. |
| Inhalation: | Remove person to fresh air. If you feel unwell, get medical attention. |
| Skin Contact |
In case of contact, immediately flush with plenty of water. If irritation occurs and persists, get medical attention. |
| Eye Contact: |
Immediately flush eyes with water; remove contact lenses, if present, after the first 5 minutes, then continue flushing eyes for at least 15 minutes. Obtain medical attention without delay, preferably from an ophthalmologist. Suitable emergency eye wash facility should be immediately available. |
| Ingestion | Rinse mouth. If you feel unwell, get medical attention. |
Most important symptoms and effects, both acute and delayed
Aside from the information found under Description of first aid measures (above) and Indication of immediate medical attention and special treatment needed (below), any additional important symptoms and effects are described in Section 11: Toxicology Information.
Indication of any immediate medical attention and special treatment needed
Notes to physician: No specific antidote. Treatment of exposure should be directed at the control of symptoms and the clinical condition of the patient.
5. FIREFIGHTING MEASURES
Extinguishing media
| Suitable Extinguishing Media | The product is non-combustible. Dry chemical, CO2, water spray or regular foam |
| Unsuitable Extinguishing Methods | None known |
Special hazards arising from the substance or mixture
Under fire conditions some components of this product may decompose. The smoke may contain unidentified toxic and/or irritating compounds.
Unusual Fire and Explosion Hazards: None known.
Advice for firefighters
Fire Fighting Procedures: Keep people away. Isolate fire and deny unnecessary entry. Contain fire water run-off if
possible.
Special protective equipment for firefighters: Wear self-contained breathing apparatus and protective suit. If protective equipment is not available or not used, fight fire from a protected location or safe distance.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions, protective equipment and emergency procedures
Use personal protective equipment. Keep people away from and upwind of spill/leak. Material can create slippery
conditions.
Environmental precautions
CAUTION: Keep spills and cleaning runoff out of municipal sewers and open bodies of water.
Methods and materials for containment and cleaning up
Spill: Mop up spills immediately. Wet floor may present slip hazard.
7. HANDLING AND STORAGE
Precautions for safe handling
Avoid contact with eyes, skin and clothing. Wash thoroughly after handling. Keep container tightly closed. Do not
breathe vapors, mist or gas.
Conditions for safe storage, including any incompatibilities
Keep from freezing - product stability may be affected. For commercial and industrial use only.
Storage stability
Storage temperature: 1°C - 49°C (34°F - 120°F)
See SECTION 8, for types of ventilation required.
8. EXPOSURE CONTROL / PERSONAL PROTECTION
Control parameters
Exposure limits are listed below, if they exist.
| Components | CAS No. | Regulation | Type of listing | Value/Notation |
| Trade Secret #000205MA104 |
Trade Secret |
ACGIH ACGIH OSHA Z-1 |
TWA STEL TWA |
NE NE 15 mg/m3 |
Exposure controls
Technical Control: Use local exhaust, or other technology solutions to keep air levels below given or recommended limit values. If limit values are not present, good general ventilation should be sufficient. Local exhaustion mat be required in some operations.
Individual protection measures
| Eye/Face Protection | Use chemical safety goggles. |
| Skin Protection | No precautions other than clean body covering clothing should be needed. |
| Hand Protection |
Chemical protective gloves is not needed when handling this material. Consistent with general hygienic practice for any material, skin contact should be minimized. In case of using gloves, use gloves chemically resistant to this material. Examples of preferred glove barrier materials include: Neoprene. Nitrile/ butadiene rubber ("nitrile" or "NBR"). Polyvinyl chloride ("PVC" or "vinyl"). Avoid gloves made of: Polyvinyl alcohol ("PVA"). |
| Respiratory Protection |
Respiratory protection should be worn as there is a risk of exposure above given or recommended Occupational Exposure Limits. If such limit values are not present, respiratory protection will cause effects such as respiratory irritation or discomfort, or when risk assessment indicates that this is required. Under most conditions, no respiratory protection should be required; If discomfort is experienced, use an approved respiratory protective device. |
| Hygiene measures | Wash hands before breaks and at the end of workday. |
9. PHYSICAL AND CHEMICAL PROPERTIES
Information on basic physical and chemical properties
| Appearance: | Liquid. |
| Color: | Clear green |
| Odor: | No odor. |
| Odor Threshold: | No data available |
| pH: | 6.5 - 7.5 |
| Melting Point: | No data available. |
| Boiling Point: | 212°F (100°C |
| Flash Point: | No data available |
| Evaporation rate: | No data available |
| Flammability: | Not Applicable |
| Upper flammability or explosive limits: | Not Applicable |
| Lower flammability or explosive limits: | Not Applicable |
| Vapor Pressure (mm Hg): | No data available |
| Vapor Density (air=1): | No data available |
| Relative Density: | No data available |
| Specific Gravity (H2 O = 1) : | 1.0 - 1.2 |
| Water Solubility: | Soluble |
| Partition coefficient: | No data available |
| Auto-ignition temperature: | Not Applicable |
| Decomposition temperature: | No data available |
| Viscosity: | No data available |
| Explosive properties: | No data available |
| Oxidizing properties: | No data available |
Other information
| VOC | 0.125% (1.305 g/L)* |
*Per Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Section 94508.
10. STABILITY AND REACTIVITY
Reactivity: No dangerous reaction known under conditions of normal use.
Chemical stability: Stable product at normal conditions.
Possibility of hazardous reactions: Hazardous polymerization will not occur.
Conditions to avoid: Temperatures above 100°F (38°C) and below 34°F (1°C)
Incompatible materials: Strong oxidizing agents. Strong acids.
Hazardous decomposition products: Thermal decomposition may yield carbon monoxide.
11. TOXICOLOGICAL INFORMATION
Information on toxicological effects
Acute Toxicity
| Acute oral toxicity |
Very low toxicity if swallowed. Harmful effects not anticipated from swallowing small amounts. Based on information for component(s): LD50, Rat, > 2,000 mg/kg Estimated. |
| Acute dermal toxicity | Prolonged skin contact is unlikely to result in absorption of harmful amounts. Based on information for component(s): |
| Acute inhalation toxicity | Brief (minutes) exposure to vapor, mist or dust is not likely to cause adverse effects. |
Skin corrosion/irritation
Brief contact may cause skin irritation with local redness.
damage/eye irritation
May cause eye irritation. May cause corneal injury.
Sensitization
For respiratory sensitization: No relevant data found.
Specific Target Organ Systemic Toxicity (Single Exposure)
Evaluation of available data suggests that this material is not an STOT-SE toxicant.
Specific Target Organ Systemic Toxicity (Repeated Exposure)
No relevant data found.
Carcinogenicity
No relevant data found.
Teratogenicity
Teratogenicity
Reproductive toxicity|
No relevant data found.
Mutagenicity
No relevant data found.
Aspiration Hazard
No relevant data found.
COMPONENTS INFLUENCING TOXICOLOGY:
Trade Secret #000205MA104
Acute oral toxicity
LD50, Rat, > 710 mg/kg
Acute dermal toxicity
LD50, Rat, > 2000 mg/kg
Acute inhalation toxicity
LC50, Rat, > 5.53 mg/L/4 hr
Skin corrosion/irritation
Rabbit, Irritating
Serious eye damage/eye irritation
Rabbit, Moderately Irritating
Sensitization
Negative in Buehler Test
Specific Target Organ Systemic Toxicity (Single Exposure)
Oral NOAEL* = 3.05 mg/kg
Inhalation NOAEL = 0.00269
*NOAEL = No Observed Adverse Effect Level
12. ECOLOGICAL INFORMATION
Ecotoxicological information appears in this section when such data is available.
Toxicity
Trade Secret #000205MA104
Acute toxicity to fish
LC50, Oncorhyncbus mykiss (rainbow trout), 158 mg/L/96 hr, NOEC Pimephates promelas (fathead minnow) 1.2 mg/L (OECD 210)
Acute toxicity to aquatic invertebrates
EC50 Daphnia magna 249 mg/L/48 hr; MPEC Daaphnia magna 4 mg/L/21 day (OECD 211 - similar substance)
Acute toxicity to algae/aquatic plants
ErC50 Pseudokirchneriella subcapitata (green algae) 400 mg/L/72 hr, NOEC 25 mg/L (OECD 201)
Persistence and degradability
Not applicable.
Bioaccumulative potential
Bioaccumulation is unlikely.
Mobility in soil
Trade Secret #000205MA104
Log Pow = -2.66
13. DISPOSAL CONSIDERATIONS
Disposal methods
| Product |
Coagulate the product by the stepwise of Ferric Chloride and Lime. Remove the clear supernatant liquid and flush to a chemical sewer. Incinerate the solids and the contaminated material according to local and federal regulations. |
14. TRANSPORT INFORMATION14.
| DOT (Department of Transportation) | Not regulated for transport |
| Classification for SEA transport (IMO-IMDG) | Not regulated for transport Consult IMO regulations before transporting ocean bulk. |
| Classification for AIR transport (IATA/ICAO) |
Not regulated for transport |
15. REGULATORY INFORMATION
Superfund Amendment and Reauthorization Act of 1986 Title III (Emergency Planning and Community Right-to-Know Act of 1986)
| Section 302 and 303 | No chemicals in this product are subject to the reporting requirements of Section 302. |
| Section 304 | No chemicals in this product are subject to the reporting requirements of Section 302. |
| Section 311 and 312 | No SARA Hazards |
| Section 313 | None |
California Proposition 65
This product contains a chemical that is at or below California Proposition 65's "safe harbor level" as determined via a risk assessment. Therefore, the chemical is not required to be listed as a Prop 65 chemical on SDS or label.
United States TSCA Inventory (TSCA)
All components of this product are in compliance with the inventory listing requirements of the US Toxic Substances Control Act (TSCA) Chemical Substance Inventory.
16. OTHER INFORMATION
| HMIS RATING | Health 1, Reactivity 0, Flammability 0, Personal Protection B |
| NFPA RATING | Special Hazard: N/A, Health: 1, Flammability: 0, Instability: 0 |
| SDS Updated | 2018-11-30 |
Legend
| US WEELs | USA Workplace Environmental Exposure Levels |
| US WEELs | USA Workplace Environmental Exposure Levels |
Disclaimer
OTHER INFORMATION: This information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any other process. Such information is to the best of the company’s knowledge and believed accurate and reliable as of the date indicated. However, no representation, warranty or guarantee of any kind, express or implied, is made as to its accuracy, reliability or completeness and we assume no responsibility for any loss, damage or expense, direct or consequential, arising out of use. It is the user’s responsibility to satisfy himself as to the suitableness and completeness of such information for his own particular use.